Quantcast
Jump to content

Honda 450 es voltage regulator

Guest Winchester300

By Guest Winchester300
in Honda ATV Forum

 Share

Recommended Posts

Guest Winchester300

Guest Winchester300

Posted
Posted

I am having a problem with my 450 es shift, have been going thru the steps in the service manual checking battery, etc. Can anyone please do me a favor and connect a volt meter to your battery, turn on the lights and rev up your engine slowly, my symptoms point to a faulty voltage regulator/rectifier, when I rev my machine up my voltage slowly drops, the higher the rev the lower she goes. mabye triggering an ECM fault, my year machine does not show the fault, you can reset by turning the key off then on and rocking the machine and using the es to shift back to Neutral to restart. I also disconnected the speed sensor and found that the voltage at the Blue/Black wire to GND was 11.25 volts dc, 1 volt less than the battery was showing, according to the manual I should get battery voltage. I have also done a leak test on the battery, 1.5 mA, which is under the 5mA by the manual, disconnected the Voltage reg. and was the same, manaul then says (faulty regulator) not sure if this is my shift problem but would sure appreciate if anyone can confirm the requests above

Thanks so much

Ajmboy Grand Master

Ajmboy

Posted
Posted

You're going to have variances with engine rpm on an atv. Most atvs I believe run 14.1-14.8 volts unless rpm is below the optimum rpm. With a draw it should not go below the battery voltage. It still could be a bad battery. You should have it load tested.

  • 2 weeks later...
Guest Winchester300

Guest Winchester300

Posted
Posted

changed the v.r., no change, did not help

  • 1 month later...
FIREMAN71 Rookie

FIREMAN71

Posted
Posted

My 300 fourtrax had similar problem with (lights dim) Discovered bad wire coming out of (one) of the two fuses near battery. Wire appeared OK (outside) Inside was bad so you may have to use OHM meter to check out

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

×
 Share
Go to topic listing

  • Popular Now

  • Similar Forum Topics

    • flyinbrian365
      2023 Yamaha RMAX4 Wolverine 1000 Service Manual
      By flyinbrian365
      View File 2023 Yamaha RMAX4 Wolverine 1000 service manual
      Factory service manual
      2023 Yamaha RMAX4 Wolverine service manual
      Submitter flyinbrian365 Submitted 06/08/2026 Category Yamaha UTV  
    • flyinbrian365
      2021-22 Yamaha RMAX4 1000 Wolverine Service Manual
      By flyinbrian365
      View File 2021-22 Yamaha RMAX4 1000 Wolverine service manual
      Factory service manual
      2021-22 Yamaha RMAX4 1000 Wolverine service manual
      Submitter flyinbrian365 Submitted 06/08/2026 Category Yamaha UTV  
    • LMI
      2005 Suzuki King Quad Battery Question
      By LMI
      Hi all.  New to the forum & quads.  Seems like a great place full of info.
      I just recently picked up a 2005 Suzuki KingQuad LTA700.  I need a battery.  I've been reading up on conventional vs AGM types.  I have a Royal Distributing and Canadian Tire.  RD has 2 types avail for my year/Model a battery YTX16-BS CRANK $75, and BATTERY YTX20CH-BS YUASA $140.  Neither of these is the type from the manual FTZ16-BS.
      from what I can tell... I think the only difference is the capacity with the $75 unit rated at 14 AH/10HR and the $140 unit rated at 18 AH/10HR ... which is the rating in the manual for the FTZ16-BS.  How much does this make a difference for nearly x2 the cost?
      And about the models/type numbers.... what is important to know ... they all end in "-BS" but are the other details relevant or just manufacturer naming?
    • flyinbrian365
      2024-2025 Polaris Ranger XD 1500 Service Manual
      By flyinbrian365
      View File 2024-2025 Polaris Ranger XD 1500 service manual
      2024-2025 Polaris Ranger XD 1500 – Official service manual Resource
      What's Covered:
      This service manual covers complete OEM factory procedures for the following models:
      Polaris Ranger XD 1500 (2024–2025) Polaris Ranger XD 1500 Crew (2024–2025) Polaris Ranger XD 1500 NorthStar / Premium / Trail Boss variants (where applicable) Manual Contents Include:
      Engine service & specifications (ProStar 1500 Flex-Fuel engine) Fuel system diagnostics & EFI troubleshooting Drivetrain, transmission, and AWD/4WD service procedures Electrical system schematics & wiring diagrams Suspension, steering, and brake system specs Clutch adjustment, belt service, and CVT procedures Ride Command infotainment system & digital cluster diagnostics Torque specs, fluid capacities, and maintenance schedules Diagnostic trouble codes (DTCs) and service tool usage Towing & payload system specifications (2,500 lb tow / 1,500 lb payload) Intended Audience:
      This resource is for owners, farm & ranch operators, fleet maintainers, and professional technicians working on the 2024–2025 Ranger XD 1500 platform. Whether you're performing routine fluid services, chasing an electrical fault, or overhauling the drivetrain on a high-hour work machine, this manual provides the factory-spec procedures to get it done correctly the first time.
      Submitter flyinbrian365 Submitted 06/04/2026 Category Polaris UTV  
    • flyinbrian365
      2018-2019 Polaris Sportsman 850/1000 Service Manual
      By flyinbrian365
      View File 2018-2019 Polaris Sportsman 850/1000 service manual
      2018-2019 Polaris Sportsman 850 / 1000 – Official service manual Resource
      📌 This thread is dedicated to the factory service manual for the 2018 and 2019 model year Polaris Sportsman 850 and 1000 ATVs.
      What's Covered:
      This service manual covers complete OEM factory procedures for the following models:
      Polaris Sportsman 850 (2018–2019) Polaris Sportsman 1000 (2018–2019) Polaris Sportsman 1000 XE / Trail / High Lifter / Touring variants (where applicable) Manual Contents Include:
      Engine service & specifications (ProStar 850 & 1000 single-cylinder EFI engines) Fuel system diagnostics & EFI troubleshooting Drivetrain, transmission, and AWD service procedures Electrical system schematics & wiring diagrams Suspension, steering, and brake system specs Clutch adjustment, belt service, and CVT procedures Torque specs, fluid capacities, and maintenance schedules Diagnostic trouble codes (DTCs) and service tool usage Intended Audience:
      This resource is for owners, shade-tree mechanics, and professional technicians working on 2018–2019 Sportsman 850/1000 platforms. Whether you're doing routine maintenance, diagnosing a fault code, or tackling a full engine rebuild, this manual has the factory-spec procedures to get it done right.
      Submitter flyinbrian365 Submitted 06/04/2026 Category Polaris ATV  

COMMUNITY SECTIONS

ATV FORUMS

QUADCRAZY MEMBERSHIP

Be a part of best online community of ATV riders and join thousands of people who love ATVs! Share your ATV photos, videos, ATV rides, get help with your ATV and more. Not a member?

SIGN UP TODAY

ADVERTISE WITH US

FOLLOW US ON

  • Automotive Webmaster
×
×
  • Create New...