Quantcast
Jump to content


1998 Yamaha Big Bear 350 - Disc Brake Conversion?


MadMan

Recommended Posts

I own a 1998 Yamaha Big Bear 350 4x2. It has hydraulic drum front brakes and mechanical single drum brake in rear. When I bought the quad a yr ago the brakes barely worked. I installed rebuild kit for brake master cylinder, replaced wheel cylinders up front, front/rear shoes, and replaced rear brake cable. The front brakes grab sort of ok now, but the rear barely grabs at all. On a side note; If I drive through any trails with muddy water, moisture is getting inside the drums. Worse in the rear drum. These drum brakes have never worked great. They slow me down but don't have enough bite to lock up the wheels. Now I have considered my drums may have worn thin, therefore causing the shoes to not make strong enough contact (???) I'm guessing. The front brakes are spooned out so they fit snug and they work just ok. The rears I have adjusted close to the maximum setting for the actuator arm. I read online about a Yamaha 1998 Big Bear 4x4 owner using a 2004 Big Bear 4x4 front disc brakes on it. He did have to dremel and drill out the lower ball joint to make new knuckles fit since the 04 knuckle has it's ball joint on bottom. It sounded cool and the owner claimed it stopped better. I'm considering a conversion, but it sounds expensive. I hate sinking $400+ worth of disc brake parts into a quad a bought for $500, and I already replaced the existing brake parts I previously listed. I'm just tired of my brakes working poorly and every time I get into some water on the trails the drums look like a septic tank inside the next day. I live in FL and this is the land of the Swamp. There is no avoiding mudholes and water. I would like some brakes that could survive any wet conditions. Any suggestions or helpful advice is appreciated.

Link to comment
Share on other sites

i have a '91 BB with drums on the front and (single) disc on the rear.

WhyTF they engineered it that way is beyond me ???

i have searched online in forums and with conversion manufacturers and have yet to see anything for the BB's. i have seen tons of stuff for honda btw. it seems the only way you can do it is to start swapping out differentials with a later model, to avoid alot of fabrication, but, there would be alot of work going that route too. i have just come to the fact that i'm stuck with drums on a 20+ year old bike and love my grizzly that much more LOL

Link to comment
Share on other sites

LOL! Very True. I came to the same thought after researching the work entailed in converting the old beast. It's a great solid atv and has never left me stranded. Luckily the engine braking on this thing works great so I can usually stop even when the crappy drum brakes are barely working. I just like to use a parking brake when I load my big bear on my flatbed trailer and this rr brake sucks. I'm in the market for a larger newer quad so I think this old machine will remain with it's awful drum brake system.

Thanks for the advice Oxi-Blk.

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Forum Topics

    • By HSTAR
      Hey I have a 1997 big bear 350 4x4
      I replaced the shifter shaft and the shift arm linkage and the rod when I installed them all I was unaware that you had to line the dot on the shifter shaft with the gap on the linkage arm gap put it all back  together and rode it I can't get it to shift in the right gears  I can move the shift cam by hand and goes in different gears but with the shifter shaft in it riding I can't put it in R or N 
      Anyone know how to line up the shifter shaft and the shift cam s
       
    • By John Sinclair
      I WANTED TO UPGRADE THE CARBURATOR ON MY 1992 BIG BEAR 350, SO I ORDERED A NEW CARB FROM EBAY.  ACCORDING TO THE WRITE-UP IT WAS A GOOD FIT FOR BIG BEARS FROM 1988 TO 1996.  WHEN I REMOVED MY ORIGINAL CARB I NOTICED THAT IT WAS DIFFERENT FROM THE NEW CARB MY CARB HAD TWO THROTTLE  CABLES THE NEW CARB ONLY HAD ONE CABLE.  HOW CAN I MAKE THIS CARB WORK ON MY TWO CABLE THROTTLE?  
    • By McG75
      1996 4x4 Timberwolf rearend width. Can someone with some knowledge of these machines answer this question for me please. Are all 4x4 timberwolves this narrow in the rearend? These tires are so close the right one actually rubs the muffler.  Thinking about seeing if there are any spacers out there for it. I need at least an inch more clearance. 
      .
       
       
    • By hardcastle
      My friends KQ 300 starts fine and runs, as soon as you put it in gear and try to accelerate its bucks and farts like crazy, not moving... I cleaned carb and it worked good for 1 day... now back to same problem.... could it be such as a bent valve????
    • By ResQ91
      Hi Guys!

      New member and could really use your advice. I would have to believe this has been an issue for others but a search here came up with nothing......? (Probably me not doing search correctly)
       
      I have an 87 Big Bear 350 YFM350FWT
      The OEM Mikuni BTM carb is shot and would rather replace than rebuild.
      It is no longer made and I have had good luck with NICHE carbs so I ordered a #K-CRB-0006 This was what they said was replacement when ordered. This Carb only uses 1 Throttle cable. The Slide is linked so it uses one. (OEM had 2nd cable coming through top to move slide)
       
      Problem is when I ordered a replacement Cable from NICHE (#C-CBL-0061) the Cable wire is a little short, not allowing Throttle to return all the way down to Idle position. I called NICHE and they are at a loss. Haven't gotten back to me after 2+ weeks.
       
      What would you recommend other than a carb rebuild?
      Can I just use 1 of the OEM cables (It is the right length) and snip/disconnect the other that went to top of Carb for Slide?
      Or ??
       
      Thanks in advance for any advice you have!!
       
      Dave
×
×
  • Create New...