Quantcast
Jump to content

  • Do you own an ATV? Join our Forum!

    As a member, you can post in our forums, upload your photos and videos, use and contribute to our downloads, create your own member page, add your ATV events, and even start your own ATV club to host your own club forum and gallery.  Registration is fast and you can even login with social network accounts to sync your profiles and content.

surbike11

2007 Arctic Cat 700 EFI NO SPARK PLEASE READ

Recommended Posts

Thanks in advance for any help or guidance. I was out riding the other day and lost all spark. I have read every thread on every forum that I could find and have not found an answer. I have checked the codes and its 00. I have ohm metered the stator and crank sensor. I have also replaced the coil pack. I have inspected and cleaned all connections. I do not mud the machine, it is mostly used at the hunting lease for working plots. When I installed the new coil I held the plug on the side of the engine and got 2 little sparks when first turning over and then nothing again. When you turn the machine over like this it eventually flashes EFI on the screen. I checked both wires that go to the coil and noticed that both have ground continuity. While turning over the blue and white one cycle from around 1v to almost 12v. The battery has a full charge and I am at a total loss. I took the kill switch apart and all looked well. Oh yea and all fuses are good. Help me please I am getting very frustrated. Thanks

Share this post


Link to post
Share on other sites


I have not checked that. I honestly figured since it was spinning over that it wouldn't be that. That said I am not even sure where the neutral safety switch is lol

Share this post


Link to post
Share on other sites

it should be on the backside of motor ... looks like an oil sending type unit, probably 1 wire ... if the safety switch is damaged, its an easy fix, all it does is allow spark when in neutral ... i have seen some bikes that have a light saying they are in neutral and no spark, replace and spark again ... hopefully this is all it is ....

Share this post


Link to post
Share on other sites


Just an update, I have ohm checked everything and pulled all plastics off. I haven't found a smoking gun. I am starting to think that it may be the ecm, any thoughts out there on that being the condition? Thanks for the help please

Share this post


Link to post
Share on other sites

last thing I had do that was an 04 arctic cat 90, did almost the exact same thing, it was the cdi box. have you checked the rectifier? I doubt that's it but I would check it. also it may sound stupid but smell the cdi or ecm, usually if they are bad they will smell burnt.

Share this post


Link to post
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.


  • Similar Topics

    • By Johnnyhorsepower
      I finally found an awsome app for your phone that shows you on a map all the trails near your location. You can read or add reviews, look at picts...etc
      Its called: atv escape

      John
    • By BuckBilly
      Good morning to all !!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
      Let's see if we can make this a daily event.
    • By George Henry
      I just watched this video I made ten years ago.  It made me laugh.  I was riding a 1985 Honda ATC 200X.  It's hard to film yourself so I had to position the camera to film me.  May flies out th wazoo, but I HAD to ride.  I hope you get a laugh.
      Here is the link: 
      https://www.youtube.com/watch?v=PNfAPe3NIg4
    • By mikeexplorer
      PA Residents, please take a moment to send an email supporting this to [email protected]
      https://www.erienewsnow.com/story/41590987/proposed-changes-on-the-way-for-riding-atvs-on-state-forest-trails?fbclid=IwAR1EXkgtnRenBzFAKG5h1IOs7xDrNg6iedYSALckbjx2F5ZPjwdDFFij6Jc#.Xic-MeQ7aXY.facebook
      This week, the Department of Conservation and Natural Resources (DCNR) plans to outline proposed policy changes for ATV trails on state forest lands.  They will also be seeking public comment.
      Pennsylvania has more than 260 miles of ATV trails in state forests. The department is reviewing its policy to respond to increasing demands for riding opportunities and well as interest from local governments in expanding tourism.
      “The purpose of the policy is to provide guidance to DCNR when acquiring, developing and managing lands for ATV use by the public,” Secretary Cindy Adams Dunn said.
      There had been a moratorium on new trail development, but the policy revisions now authorize DCNR to consider new ATV trails and connectors on state forest lands.
      “New ATV trails will be considered, while still balancing the protection of natural resources as outlined in the Environmental Rights Amendment to the Pennsylvania Constitution, and the needs of all types of recreational users on DCNR lands,” Dunn said.
      In a 2016 survey of ATV users, more than 4,800 responded with many indicating a strong desire for more long-distance trails. Pennsylvania has around 285,000 registered ATVs. On state forest lands, ATV riding is allowed only on designated trails.
      Public comment will be taken at a meeting in Harrisburg Wednesday, January 22, from 10 a.m. to noon in Room 105 of the Rachel Carson State Office Building. Written comments can be submitted to [email protected]
      The deadline to submit comments is March 27.
      More information about ATV riding is on the DCNR website.

    • By Relais22
      "Greetings from LaTuque Quebec! Please come and visit us at Relais 22 this summer, and bring your ATV. We have special prices and 10% off gas for you this summer. Thanks! Click here: ATV Holiday in Canada"



  • Similar Tagged Content

    • By mikeexplorer
      Wiring diagram for 2007 Arctic Cat 700 EFI 4x4
       
       
    • By gregj49
      Blows out black smoke when you rev it up how do you adjust the carb?
    • By Barrysquad
      Somehow I lost all of my spark on my 350Big Bear, its a 1990. It ran well for maybe 3 days! Thought it was the carb. Cleaned it 4 times. It was losing power at midrange. Got worse and worse. Finally nothing!
      Are these good coils? I was thinking I could swap?
      2002 Honda-200cc: primary 0.4(ohm-200) secondary 9.0(ohm20k)
      1990 Yamaha-350cc: primary 0.8 secondary 11.0
    • By toonces
      I'm wanting to run Shell Rotella T6 synthetic in the 700 Griz but I can only find it in either 0W-40 or 5W-40 weights, and the manual says it's ok to use everything BUT those weights...5W-30, 10W-30, 10W-40, 15W-40, 20W-40 and 20W-50.
      Would it be ok to use the Rotella 5W-40 or do I need to stick to what's specified in the manual?
  • Recently Browsing   0 members

    No registered users viewing this page.


×
×
  • Create New...