Join Today, It's Simple and FREE!
As a member, you can post in our forums, upload your photos and videos, use and contribute to our downloads, create your own member page, add your ATV events, and even start your own ATV club to host your own club forum and gallery. Registration is fast and you can even login with social network accounts to sync your profiles and content.
By Dra O
posted a while back - it was running at one point - I have all the plastic shroud off - it's down to frame and engine now
-fuel pump: when line from petcock is attached, no fuel comes out other side to carb; the line to the carb is open (can blow through it); I thought when I cranked engine that the pump would spit out fuel on other side but it does not; I removed fuel pump and opened it up - diaphragm looks good - but internal areas had lotsa calcification build up - I cleaned this out and dried it good - the clear plastic pieces (?diaphragms) aren't broken - the spring w/ steel ball on end moves freely; am putting it back on tomorrow; but can anyone answer about the pump? isn't it supposed to pump fuel through it... to other side... to carb? puzzling
-along with fuel pump: I replaced petcock 3 weeks ago (gas tank had rusty fuel in bottom - cleaned it out prior to new petcock); when I turn petcock arrow NOT to on or reserve, fuel comes out of line; when I turn it to on or reserve, fuel doesn't come out; puzzling
-I don't know what's on back of fuel pump - it's a valve that has a hose coming out of it - looks like it goes to engine/carb - I haven't traced this out yet - what is it?
-can squirt gas on air filter and engine will run for 2-3 seconds then stop - fuel in top of carb (under diaphragm) does same
-it likely needs carb rebuild - will get to this - but something isn't allowing fuel to get from fuel pump to carb
-I THINK it has a mikuni model x carb - diaphragm is ID 26mm OD 68mm - hard to find inexpensive diaphragm, I guess because it's a model x
-last thing - I replaced solenoid due to old one clicking; I HAVE to be charging the battery or it won't start/turn over - battery just goes dead; but if charging, it'll turn over nicely; i'm guessing it's a bad battery
-any help appreciated - I've never owned an ATV before - inherited this beast from grandparent in-law
I am new to this forum and hope that someone out there can help me, I have an early Suzuki King Quad 300 (280cc) which starts intstantly every time but at about half revs or there abouts it starts spluttering and will not rev any higher, this fault is present whether choke is applied or not, some one suggested that silencer maybe be clogged so removed baffle but no improvement have removed carb and stripped 3 times but still no joy.
Any ideas would be most welcome.
1987 Suzuki LT 80 and 2007 Honda CRF 50 dirt bike stolen out of my driveway on July 4th. Anyone with info that recovers them will get $400 no questions asked.
The post Suzuki LT 80 Quad And Honda Dirt Bike appeared first on STOLEN 911.
View the full article
By Monika Novakov
1988 Kawasaki 220 Bayou trying to remove generator/ starter 1way clutch cover to be able to replace 1way clutch. All bolts are removed case cover is dripping what oil that remains...but I can't get the cover to come off..what am I missing? Thx in advance.
replacing carb,, the bigger line on right side top of carb does it just vent to the air,, cant find where to hook it up to also I want to check the oil and gear oil I checked the oil in motor and the rear end my question is looks like allen plug on left side of motor if you are setting on the 4 wheller, ps it hs a oli leak any help would be great. Ray in kentucky
Similar Tagged Content
By Mo Salem
So my front hub broke, I’d like to put aftermarket on. Hard to find new oe ones. Please help. I’m new to all of this, I have some car knowledge and try to apply it
I'm starting this thread to list the ATVs and UTVs that currently have Bluetooth connectivity as OEM and any aftermarket products out there. Lets list and have a discussion about any new devices or atvs that are coming to the market with Bluetooth connectivity. This is probably biased towards atvs with electronic dash clusters, but with the technology changing so fast, it's good to know what's new and up 'n coming.
I read this on ATVRider...
Polaris Sportsman XP1000
The top of the line Polaris Sportsman XP1000 has an instrument cluster that features Bluetooth connectivity. This way, if you get a phone call, voice mail or text while out on the trail, you can glance down at the screen and decide if its important enough to stop and dig your phone out of your pocket.
How many atvs with electronic dashboards do you think will start to have this type of connectivity?
Check out Polaris' Ride Command: http://www.polaris.com/en-us/atv-ranger-rzr/touch-screen
my son has a 50cc Baja atv automatic trans that at time (right now) jerks then dies, once he trys to start it the starter causes the quad to lunge forward like the clutch is not releasing. when this happens, you cannot push the quad backwards either even with the engine off. if you raise the rear on a block it will start but the rear wheels will spin even at idle, if you pull the quad off the block the load of the machine will instantly kill the engine. im guessing its a stuck clutch issue however I cannot find any info anywhere. im an ase master auto tech so I am pretty mechanical just need a point in the right direction. any help would be greatly appreciated. thank you in advance!
Recently Browsing 0 members
No registered users viewing this page.