Search the Community
Showing results for tags 'vinson'.
-
So just acquired this 2002 Suzuki Vinson LT-A500F and am in the beginning process of getting it to run. I found two small screw size holes in the top of the tank, it would appear someone was not careful screwing something down to the plastic cover and accidently damaged the tank. My preface is to replace the tank but I am not finding any available, so can anyone give me any advise on this. If I do not find a suitable one at a reasonable price I will look at possible doing a epoxy type repair on this one. Next is the fuel gauge, its missing and is creating another hole in the tank. I found this ONE which looks like it on ebay but the seller does not include any dimensions to verify. So any advise on this will be greatly appreciated as well. I did see the post on changing the fuel petcock with the Yamaha on/off valve which I have ordered already.
-
View File 2000-2001 Suzuki Vinson LTA500F Service Manual Vinson LTA500F service manual Submitter Mech Submitted 12/03/2022 Category Suzuki ATV
-
-
out of the blue my vinson wouldn't shift into park and when I am in H or L and go past a slow pace (maybe in 2nd gear) it grinds and Low grinds even louder. It sounds as though it may be in the rear diff. I have not tore into the rear end or anything yet. I was looking for advice before tearing it apart. Reverse has no grinding at all and H gear doesn't grind until you get moving past a walking pace. L grinds as soon as it moves. It shifts into gear smoothly and 4wd works just fine. There was no issues leading up to this. Any advice is appreciated thanks.
-
My Dad's 03 Manual Vinson has milky oil. He changed oil and ran it everyday for a week being sure to keep it running for an hour each time. Fresh oil is getting milky again.. Thinking it's the water pump seal. Has anyone here successfully changed the seal or even replaced the whole pump assembly?
- 5 replies
-
- vinson
- suzuki vinson
-
(and 1 more)
Tagged with:
-
Having serious problems with quad it completely stopped running on me took carb off and tore apart cleaned everything put back on and it started idled but when driving it had no power at all so took carb back off and noticed their was a puddle of gas and oil in the bottom of the air filter box and also their was gas in the vacuum line HELP
-
Im having a problem getting the left side of my engine case apart so i can fix my starter gear issue .can anyone share some guidance i have all bolts that i know or havent managed to remove hi lo shifter
-
Hello. I'm wondering if I have to split anything to replace the rear u-joint on my ATV? Will the driveshaft pull out of gearcase, or does case have to be removed and split?
-
I've changed my stator and pick up coil. I've verified new stator specs are correct and I have a good ground at the cdi. Also verified continuity from all stator wired to cdi and rectifier which is also new. I have a source voltage but no trigger voltage. It's a 2005 Arctic Cat 500 Suzuki Vinson motor. Any help would be GREATLY appreciated. I've spent about 2 weeks troubleshooting this and can't seem to find this exact scenario on any forum. Tjanx again for any input!
- 1 reply
-
- arctic cat
- 500
-
(and 1 more)
Tagged with: