Search the Community

2005 Suzuki KingQuad 700 4X4 LT-A700X A bundle of wires taped together shorted and melted tape. After removing tape, the wires fell apart and there was no way to determine how wires connected. This is on the left side of the ATV (see attached pic). None of the wires run to ground. None test for volts with key on or when ATV is running. There are 4 wires that go into 3 wires. 4 wires come in from above – yellow/green stripe, white/brown stripe, green, brown. 3 wires are below – all are yellow w/o stripes & and bundled into chase with a blue & a green wire that pass through (see attached pic). The 3 yellows appear to come from generator. ATV only runs off battery now. There is no charge back to battery and ATV dies upon disconnecting battery (with RPMs up). All fuses are intact. It would appear that any wire can connect to the yellow wires, so no worries there. But the extra/4th upper wire needs to be connected or bundled with one of its mates and I have no idea which goes to which. Any help greatly appreciated.

I just got a 1996 Kawasaki Bayou 220. The wiring is a bit of a mess. My question is I have a white wire and a black/yellow wire that aren’t connected to anything. They’re both located under the seat. The bk/y wire comes from where it splits I think 3 different ways. I’ve checked the diagram and I’m still having no luck. Also are the only wires connected to the ignition switch the brown and the white one? Any help it’s appreciated. Thanks.

I need help with wiring on a 1998 (I think, 10th digit of the VIN was W) Bayou. I'm not getting spark, I'm pretty sure it is due to grounds being off because the harness is pretty hacked as far as the electric start and charging system goes. I'm needing a good wiring schematic. I found one online and there are a few things that don't add up on it so I'm skeptical that it is really for my year and model. Any help would be appreciated. Thanks.

Here is what I have collected over the years and maybe it will help someone else. There are so many and several are too large to upload as attachments, so see any thing you need just shoot me a PM and your email and I will get them on the way to you as fast as I can. Thanks 50cc to150cc Service Manual For Tank Motorsports.pdf linhai-atv-service-manuals-linhai-300-parts-manual.pdf 1986 CH250 ELITE SERVICE MANUAL.pdf Charging and ignition systems for atvs.pdf Chinese ATV Frame Diagram.jpg Chinese ATV Repair Shop Manual - Clutch Diagram - Exploded Views.jpg Chinese ATV Repair Shop Manual - Cylinder Head Diagrams.jpg Chinese ATV Repair Shop Manual - Torque Specifications.jpg Chinese ATV Repair Shop Manual - Valve Clearances.jpg Dinli-501-PARTS-DINONP.pdf Dinli-601-Parts2003BEAST-DIAMONDBACKNP.pdf Dinli-DL-5015erviceManual.pdf Dinli-DL-502PartsManual.pdf Dinli-DL-5025erviceManual.pdf Dinli-DL-503PartsManual.pdf Dinli-DL-601,DL-603ServiceManual.pdf Dinli-DL-603PartsManual.pdf Dinli-DL-604PartsManual.pdf Dinli-DL-701PartsManual.pdf Dinli-ServiceManual-150ccATV.pdf DTE150-2-150cc.pdf Eagle ATV Fender Body Parts Exploded Diagram.jpg Eagle ATV Rear Axle - Exploded Diagram.jpg GY6_150cc_ENGINE_PARTS_157QMJ_.jpg GY6_Top_End_Rebuild.pdf Leopard-parts.pdf Linhai_260servicemanual.pdf Odes-400-Repair.pdf Piston Ring Installation 4 Stroke Engines.jpg Roketa-ATV-10(ATV-DO43)-Repair.pdf Roketa-ATV-11(ATV-D037)-Repair.pdf SLA-120-PARTS.pdf SLGK-110-PARTS.pdf SLGK-150R-PARTSMANUAL.pdf SLGK-400R-PARTS.pdf SLU-500-600-700-PARTS.pdf slu700db-700UTV-Service-Manual.pdf tao-tao-atv-parts-cylinder-rebuild-kit-for 90cc-100cc-110cc-engines-p-13331.pdf Trouble Shooter Guide for BATTERY DRAINED Chinese Engines.txt Trouble Shooter Guide for NO-COMPRESSION.txt Trouble Shooting No Crank.txt Troubleshooting.pdf YX125CC BREAKDOWN.pdf _________________________________________________________________________________ 50 to 150cc GY6 Shop Manual.pdf Arrow 150 Engine Service Manual.pdf Eton Shop Manual YXT-150.pdf GY6 Shop Manual.pdf Yerf Dog Spiderbox GX150 Service Manual.pdf

OK I took my starter solenoid apart to clean it as I was hot wiring it with a screw driver for ever and then last time it burned up my ecu I think I heard it's called anyways u don't need that part I read but I looked forever for it to replace it they discontinued it so I got a new solenoid as my was toast and now I need help hooking it up with all my wires I also have a wench so adds a few more and I'm clueless thanks for helping this Montana women out. And please help her out thank u. Here is a Pic of my solenoid tkx again

Where can I find a wiring diagram for my 2005 450 Kodiak. Thanks.

Hi guys has anyone any advice or know where to get a wiring loom cheap? Someone has cut the plug that plugs into the relay so its now as seen in picture whats best way to sort this?

new racing cdi trz50 wiring for predator 90 cdi has a green and yellow wire going to a 2 pin plug and has a red a black and blue with bullet connectors what wires go were on the the ate wiring harness and how would i wire if i want to bypass the atv harness

Hello folks, I have a yamaha timberwolf 250 motor I'm putting into a tri moto 200 frame and need some help with the wiring for it. The wiring harness I got with the motor has been damaged and missing a small section so my issue is that I have 3 white wires coming from the stator assembly which connect into another 3 white wires on the voltage regulator. My question is does it matter which of those white wires go connected together or are each of the white wires different and need to be connected to the appropriate wire on the voltage regulator. Any advice or help is appreciated. Thanks.

Hey just picked up another scrambler 850 was told the tps was bad. This atv has been beet to hell. Wiring has been tinkered with the crankcase has been replaced recently and the motor rebuilt (can see horizontal scores thru spark plug hole where it’s just been honed out and rebuilt) my guess is it was ragged out till the motor blew a rod and rebuilt but the clown that did it couldn’t get it to run again and sold it. When I bought it it would pulse and smoke black at idle and die with throttle. New tps installed and it won’t run period. I went to celebrate it and I’m getting 5 volts on 2 of the 3 wires running to the tps. Is this normal and if so how should I celebrate it?

Has anyone had any luck putting a different gauge on this machine. Would you happen to have the wiring diagram?

Hi guys im new here and ive been doing alot of research on my polaris predator i was wondering if anyone on here has wired a different cdi up on there quad? Not a direct replacement that would simply just plug in. I know my white an w/red wires go to my pulsar my green an blue go to my reverse coil but im unsure which is + and which is ground also brown/w is a ground correct? What about purple? Black goes to my kill switch and red is my 12v supply........then ive got yelloww/red , yellow / yellow that goes to my rectifier..........any input on this subject is greatly appreciated thank you all

View File 1999 Polaris Magnum 500 Wiring Diagram Wiring diagram for 1999 Polaris 500Magnum Submitter davefrombc Submitted 09/08/2019 Category Polaris ATV  

New arctic cat owner, I've read alot on the gauge issues, but let me say I have power, good ground, the aux also has power, the memory has correct voltage but no output of any kind. Only the LCD color works. I have also fully removed EVERYTHING and cleaned it all... what I still possibly have a cut wire knowing that I have good power to the back of the plug and good ground to the back of the plug but no outputs of any kind?

So here's my situation.i picked up a super clean 225 moto 4 but the cdi has been cut off.i have numerous different cdi units and just can't simply afford to buy anything currently.im sure I can make something work I'm just seeking a little advise or ideas or thoughts. Any help would be greatly appreciated.thank you

I traded my dirt bike for a 2000 arctic cat 500 semi automatic. when i went to go pick it up the guy said it didn't get spark, so i thought it was going to be something simple like a coil. well it wasn't. first thing i did was take all the plastics off to get easy asses to every thing. so i bought a brand new battery for it seeing if it got power, it didn't. the dash wouldn't light up neither would the lights, so then i tried to see if the starter worked it didn't so i jumped the solenoid and the starter started turning over the motor. so i bought a new starter solenoid, when i installed it the electric start still wouldn't work , so i bought a new kill switch and starter switch that goes on the handle bars, when i installed it, the electric start still wouldn't work. so then i went to see if i could get spark by pull starting it, i didn't get any spark, so i bought a new spark plug, and guess what, still no spark, so then i bought a new coil for it to see if that would fix it. so i installed the new coil and guess what no spark still and still no power to the dash. so to sum it up i'm not getting any power any where to the four wheeler. so i cleaned all the leads and plugs and still nothing. so then yesterday i took the wiring apart to see if their was any frayed wires, and no their wasn't. does any one have any ideas what this could be i'm up for anything. also if any one knows how to bypass all the wiring just to get it to start i open to that to, or if someone knows where i can get a wiring diagram.

Long story short, I purchased a basket case over the weekend. I spent most of last night repairing melted wires and generally tracking down everything. I am able to locate all the connectors but have a two pairs of blue and brown wires left over (one on a long pigtail, like it should be going to the back). The wiring schematic in the manual does not show them (though they are part of the factory harness) and I only find one indication of them in a US/Canada wiring schematic (Clymer, I believe) which does have them but it says they're for US only. Does anyone have an idea of what these wires are for and/or have them them hooked up to anything?

View File 2005 Polaris Sportsman 700 EFI & 800 EFI Wiring Diagram This is the wiring diagram page from the service manual for a 2005 Polaris Sportsman 700 EFI & 800 EFI. Submitter quadmaniac Submitted 10/05/2017 Category Polaris ATV

Hey Guys! I have a Problem with wiring my 2007 Yamaha Warrior. i replaced the main wiring and now i don´t know, wich cabel must be conected to the spark plug coil. It´s the only Thing, that keeps me from driving, so please help me!!! (i mean the big part shown the Picture below)

Wiring diagram for 2007 Arctic Cat 700 EFI 4x4