Do you own an ATV? Join our Forum!
As a member, you can post in our forums, upload your photos and videos, use and contribute to our downloads, create your own member page, add your ATV events, and even start your own ATV club to host your own club forum and gallery. Registration is fast and you can even login with social network accounts to sync your profiles and content.
Similar Tagged Content
Below is a quote from a response to similar question from yesterday:
"Easiest thing to check is trash in the main jet. if it idles fine, then the idle circuit and low speed jet is clear. if it bogs off idle that's when it's transitioning to the main jet."
I will go ahead and open up the carb and check the main jet, but please respond to this post as if the main jet is squeaky clean.
Below is my post:
Only starts and runs on Full chock.
Does not matter what position I have my "mixture" screw. Tried it at zero, 1 turn, 2 turn, up to five turns. Spent a few hours confirming that the position of the mixture screw does not resolve issue.
Runs great at idle and if I slowly engage throttle, it will rev up as expected. But, quick rev up or when I am trying to drive it, it spits and sputters and looses power.
I also use a propane bottle and did not find any obvious leaks, and the vacuum port is hooked to fuel peacock and I also made sure to simply block the port with my finger to see if that would resolve the issue.
New Carb (after market), New Coil, Fresh Gas. No leaks at manifold boot, hot battery. Good gas flow. Runs too good to be a valve issue, or cylinder, great compression.
I can move the choke out a tiny bit, and it will still run, but will still bog down when I try to power it up.
I also have a 250 trail boss Polaris that I require to run at full choke, but it has power at all throttle potions.
I suspect it is running rich as the choke is on, but will not run with it off.
Any details would be appreciated.
I just bought these in the fall as a pair and of course they were running awesome with no problems at that time.
One of them now will only start with starting fluid. It runs great once it's started, but absolutely refuses to start without a squirt of the good stuff. The other one starts just fine, but dies after it gets warm. The only way to keep it running is to keep the throttle up. It won't run at an idle, and keeping it running has the throttle too high to shift. Any ideas or suggestions are very much appreciated!!!
John from Shelley, Idaho
I have a 2001 suzuki quadmaster 500 4x4 that has a rev limiter when it is in any gear other than neutral, i have already fixed a bunch of stuff on it and would love to just bypass it if anyone knows how. Thanks for any help.
By Mike Johnson
Hello again guys ,. I have a Quadmaster that has a very bad lean to my passenger side wheel. I replaced the a arm bushings with no change in the lean, I see no bent parts and no adjustments available. It's always been there since I got it but became really noticeable when I put the lift kit on it. I'm going to add a picture of the problem if allowed.
By Stephanie Webb
please help cant figure out how to bypass rev limiter in my suzuki quad master 500
By ronald webb
So where to start my son's LT80 stop running a couple months ago. Naturally I assumed I had a carburetor issues or the peacock valve. After replacing those two items and ensuring I had a spark I started doing my homework thus finding this page. After all the post I have read the next natural thing would be compression I did a compression test today and it was only 60 after spraying WD-40 in it so off comes the cylinder head and The Jug to my surprise the cylinder walls and all the gaskets are pristine so I am totally stumped no idea why I would not have compression when everything looks brand new even the Rings look great any help would be appreciated thanks in advance
I have a 99 250 Quadrunner. Currently has no spark. It would run for 5 minutes, then shut off. After it cooled down about 20-30 minutes, it would start again. I ordered a new stator and found the old one was damaged (copper windings broken) I installed the new stator, filled with oil and now it has no spark. Any assistance would be helpful
these are what i have in my collection ... always looking for more
1985 - 1995 Polaris All Models Service Manual
1996 - 1998 Polaris All Models Service Manual
1996 - 2003 Polaris Sportsman & Xplorer 500 Service Manual
1996 - 2003 Sportsman 400 & 500 ~ Xplorer 500 Service Manual
1999 - 2000 Polaris All Models Service Manual
2001 Polaris 90 Service Manual
2001 Polaris Scrambler 50 ~ 90 Sportsman Service Manual
2001 Polaris Sportsman 500HO Parts Manual
2001 Polaris Sportsman 500 Parts Manual
2002 - 2003 Polaris Sportsman 600 & 700 Servive Manual
2002 Polaris Sportsman 700 Service Manual
2003 - 2005 Polaris Magnum 330 Service Manual
2003 Polaris Predator 500 Service Manual
2003 Polaris Predator Parts Manual
2003 Polaris Trail Blazer 250 Service Manual
2003 Polaris Trail Boss 330 Service Manual Part I
2003 Polaris Trail Boss 330 Service Manual Part II
2003 Polaris Trail Boss 330 Service Manual Part III
2004 Polaris Predator 500 Owner's Manual
2004 Polaris Sportsman Owner's Manual
2005 Polaris 400 & 500 Sportsman Service Manual
2005 Polaris 700EFI Owner's Manual
2005 Polaris 800EFI Owner's Manual
2005 Polaris Sportsman 400 Parts Manual
2005 Polaris Sportsman 500 Parts Manual
2005 Polaris Sportsman 6x6 Owner's Manual
2005 Polaris Sportsman 700EFI & 800EFI Service Manual
2005 Polaris Sportsman 800 Twin EFI Parts Manual
2006 - 2007 Polaris Outlaw 500 Service Manual
2007 Polaris 700 800 800x2 EFI Service Manual
2007 Polaris Ranger 700EFI 6x6 Parts Manual2007 Polaris Ranger 700 4x4 & 6x6 Service Manual
2007 Polaris Ranger XP 4x4 Service Manual
2007 Polaris Sportsman 450 & 500EFI - 500X2EFI Service Manual
2007 Polaris Sportsman 700 800 - 800EFI Service Manual
2008 Polaris Sportsman 500EFI & 500x2 Service Manual
2008 Polaris Ranger 6x6 700EFI Parts Manual
2008 Polaris 800 RZR Service Manual
2008 Polaris Sportsman 700x2 - 800EFI - 800 Touring Service Manual
2009 Polaris 850HD EPS Service Manual
2009 Polaris Outlaw 450 & 525 Service Manual
2009 Polaris Outlaw 90 Service Manual
2009 Polaris Predator 50 Service Manual
2009 Polaris Ranger 2x4 Service Manual
2009 Polaris Ranger 4x4 Crew Service Manual
2009 Polaris Ranger 500 2x4 Service Manual
2009 Polaris Ranger 500EFI 4x4 Service Manual
2009 Polaris Ranger 500EFI 4x4 Service Manual
2009 Polaris Ranger 700 4x4 Crew Service Manual
2009 Polaris Ranger 700 4x4 Service Manual
2009 Polaris Ranger INTL Service Manual
2009 Polaris Ranger RZR 170 Service Manual
2009 Polaris Scramber 500 Service Manual
2009 Polaris Sportsman 300 & 400HO Service Manual
2009 Polaris Sportsman 450 & 500X2 Service Manual
2009 Polaris Sportsman 500 Service Manual
2009 Polaris Sportsman 6x6 800 Service Manual
2009 Polaris Sportsman 800EFI & 800EFI Service Manual
2009 Polaris Sportsman 550XP Service Manual
2009 Polaris Sportsman 850XP Service Manual
2009 Polaris Trail Boss - Trailblazer 330 Service Manual
2010 Polaris Ranger RZR S Service Manual
2011 Polaris Ranger RZR S Service Manual
2011 Polaris Ranger RZR SW Service Manual
2012 Polaris Sportsman 400 Service Manual
Visit the Polaris Service Manual Section: https://www.quadcrazy.com/files/category/7-polaris-atv/
View File 2009 Polaris Ranger 700 4X4 Crew / 6X6 Service Manual
2009 Polaris Ranger 700 4X4 Crew / 6X6 Service Manual
Submitter Ajmboy Submitted 10/31/2020 Category Polaris UTV
Recently Browsing 0 members
No registered users viewing this page.