Quantcast
Jump to content

Recommended Posts

Posted (edited)

hey guys, just put in a new stator on my warrior and now I have no spark at all. Could anyone give me some advise here? I think if I was close to a cliff right now I would push this quad off of it. Thanks in advance. Ok last night I was messing with the wiring and tried to start it and i started getting spark. So i put the plug back in the motor and then nothing. I can pull start it and it will run but it is backfiring like crazy. It ran great until the stator went bad now all these problems. Any advice would be great

Edited by jjsoren
add more info
Posted

sounds like the timing is 180 out... shouldnt be related to the stator tho... pull the plug and pop off the timing cover- make sure everything is where it should be...

make sure your valves are closing too- it is commonly overlooked and easy to do.

Posted

Thanks for the reply. I have checked the timing it is right on. As for the valves I have not checked. The funny thing is it ran fine 4 days ago then the stator went out I replaced the stator. So I checked for spark and when I used the electric start it was random when I would get spark. One time I would get spark the next nothing. So I tried pull starting it and it started right up but now it has a backfire out the tailpipe none stop. The stator is good because it has a bright blue spark and the spark will jump a 1/2 inch to ground out. This is just so frustrating I just want to RIDE!!!:aargh::aargh:

Posted (edited)

Thanks MIKEL5469. I downloaded one earlier. I noticed when I was testing everything that the plug would have a small spark when I would first hit the start button. I just can figure out why I can pull start it but it wont start using the electric start.

Edited by jjsoren
Posted

Weak battery might be why it wont start with the electric start. How did you check the timing? How did you come to the conclusion that you had a bad stator? A bad coil or pulsar coil coul be causing you problems, I would test those and make sure they are good.

Posted

I have replaced battery, coil,stator,pickup coil, checked timing, talked to yamaha mechanic and he said it sounds like the cdi. He said the problem with electrical is if one part goes bad its a chain reaction because everything else tries to make up for the failing part. I purchased a new cdi, I will let you guys know what happens Thanks for everything

Posted

Thanks everybody for the help. I replaced the cdi and it still wouldnt run. So, I went through everything again. Tested the pickup coil and the ohms tested low replaced it again and the fourwheeler started right up runs like a champ. I was told that more then likely the cdi box shorted it out. who knows I am just glad that it works. Thanks again

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Forum Topics

    • By docdoug72
      Has anyone had a suzuki 230 quad lock the engine up?  Its a well maintained bike, it locked up when my son was riding it. Pulled the plug, it has connected with the piston. I'm thinking the con rod let go.  I don't have a service manual.  Does the engine need to come out to check further?
    • By RGS
      1989 Moto 4 YFM350ERW intermittent spark.
      Quad has set for about 7 years and was running when parked.  When I replaced the battery and attempted to start it had no spark. 
       
      What I have done.  Followed troubleshooting in the manual. 
      1.       Coil failed the resistance check so I replaced it.  Still no spark.
      2.       I performed resistance checks on the stator and they all pass.
      3.       Found a bad rear brake stop switch and unplugged it and connected the wires in order to disable.  Now I have intermittent spark.  I believe that the issue is with either the stator or CDI and not sure which.
      1989 seems to be a transition year for electrical.  I can get new aftermarket CDI units for 87-88 and 90-94.  I cannot get ones for a 89.  I can get new stators for 87-89 and 90-95.  Looking at the schematics the wiring on my moto is closer to the 90 ones on the ATV side of the CDI and closer to the 87-88 on the stator side of the CDI.  Looking at part supply sources the stator housing is the same part # for all the years and looking at some of the stators on Amazon that have the dimensions on them both of the stators are the same size.
      What I am thinking of doing is to replace the stator and CDI with a 90-95 one as these parts are all readily available.   Does anyone know if this has been tried before and if there are any issues with doing this.  
       As a side note I also have a 1993 Moto 4 YFM350ER that has been sitting longer but it is located about 400 miles from me at this time.  By doing this change in addition to being able to get parts I will also have 2 ATV’s that are the same electrically. 
    • By Suzukiquad
      Hi, I have been around everything with a motor since I was little, and finally purchased more to get my husband, and kids involved. I have 4 quads I will be searching around for information on. I have two 2002 Suzuki LT80K quads, a 1997 Yamaha Timberwolf 250, and a 1996 Kawasaki Bayou 220. I have had different ones throughout the years, and plan on buying another Yamaha Banshee. I plan on trying to learn more about all of them, so I can customize some of them. I know nothing about them besides how to race them, my dad always took care of the rest, but figured it was time for me to learn. 
    • By Thekevinjb
      Can anyone provide information on connecting a hitch to a Polaris. Anyone know where they sell small trailers for my quad. 
      thanks
    • By RadRob
      I am new to this site. I have a 1987 Suzuki LT230S Quadsport I think. Is there a difference between quadsport and quadrunner?
×
×
  • Create New...