Quantcast
Jump to content

  • Join Today, It's Simple and FREE!

    As a member, you can post in our forums, upload your photos and videos, use and contribute to our downloads, create your own member page, add your ATV events, and even start your own ATV club to host your own club forum and gallery.  Registration is fast and you can even login with social network accounts to sync your profiles and content.

tom reed

1990 Honda Fourtrax 2WD Hard shift

Recommended Posts

May be some of you guys can help me, I've got a 1990 honda four trax 2 wheel drive, the top end has been completely rebuilt. When I bought it barely ran, so I had everything redone BUT, it shifts good until the motor gets up to running temp and it starts getting hard to shift and the longer you run it the worse it gets, it will get so bad that it is almost impossible to get it into reverse. Does anyone know what wrong?

  • Like 1

Share this post


Link to post
Share on other sites


@tom reed Added ATV info to topic title and moved to Honda ATV forum. 🙂

Share this post


Link to post
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.


  • Similar Topics

    • By dbconn55
      Hi guys I have a 2003 Arctic 250 4X4 it starts idles and runs great for about 10 min. then it spits and sputters and dies but it starts right up like nothing happened idles good till you give gas and it does it again let off the gas and it's idling great again this goes on for about 15 to 20 min. and then it takes off runs good all day like nothing was wrong.
      I cleaned the carburetor it looked like a new one inside found a little gunk in one orifice, new air filter no crimped lines air line to tank good I did put a meter on the battery idling it said 16.5 V that's high I think would a voltage regulator cause this?
      Suzuki shop wanted to sale me a stator for $556.00 but said it could be something else also thought I'd see what you guys say about it
      Thanks
    • By Tahj
      I bought a 2003 Recon from a kid that beat it – all plastics cracked etc, When I replaced the rear brake the inside – axle, rear oil  - were clean and in good shape, so I think Honda won the kid vs quad battle.
      It shifts a little clunky (I made the adjustment) and after riding for a while I get a hot friction material smell I wonder if he used the wrong oil and if any damage was done.
    • By MarkinAR
      Couple of quick points:
      1. the Odyssey, or FL350R. This was 30 years ahead of it's time.  Fast as greased owl crap, reliable, stupid fun.  Never took off.  Fast forward to the RAZR which was just replicating the FL350R.  What would Honda have done with it if it took off in '85?
      2. Everything about the ATC.  Reliable, good power for small displacement, easy to work on, simple front to back, still running 30 years later.  My son's 185s is 36 years old and outran a 400 Big Bear the other day until it ran out of gearing and the Big Bear caught it around 50 mph.  I can dig a 110 out of the weeds and as long as it has a little compression, I'll make it run in 2 days for about $20.  Can't do that with a Yamaha 225.
      3, 1981 250R.  What happens if you stick a CR250 2 stroke in a trike?  Yeah, a death machine.  Then by '85 the 250R had a 6 speed and would do 70 from the factory.  Death Machine +2.  The 250R gave birth to the trike racing circuit.
      4. The ATC 70.  Small, quiet and reliable.  Just never took off.  Gave birth to the entire small displacement chinese quad market.
      5. 82 200ES - first Big Red.  The BR single handedly created the UTV market as we see it today in the Ranger, Mule, etc.
      6. The ENTIRE chinese quad market in front of us today came from expired Honda patents from the 80's.
      7. 300 fourtrax.  By far the most coveted 4x4 in the market right now, absolutely indestructible.  Pick one up a couple of years old, stick massive wheels and tires on it, and you have a mud machine.  Kinda like the Polaris or Can Am...but reliable.  And cheap.
      To be fair, Yamaha, Suzuki, Kawa, all picked their game up along the way and make good ATV's.  I'll leave the Polaris/CanAm discussion for another day.  While Polaris gave birth to the automatic, the reliability issues of both still exist today.  While great ATV's, I don't consider them any more than specialty machines.
       
      FIGHT ME.
      or debate...whichever is easier.
    • By lanow
      Hi Everyone,
      I am new to this forum and hope that someone out there can help me, I have an early Suzuki King Quad 300 (280cc) which starts intstantly every time but at about half revs or there abouts it starts spluttering and will not rev any higher, this fault is present whether choke is applied or not, some one suggested that silencer maybe be clogged so removed baffle but no improvement have removed carb and stripped 3 times but still no joy.
      Any ideas would be most welcome.
      Cheers Rob
    • By StolenATV
      1987 Suzuki LT 80 and 2007 Honda CRF 50 dirt bike stolen out of my driveway on July 4th. Anyone with info that recovers them will get $400 no questions asked.
      Thanks
      The post Suzuki LT 80 Quad And Honda Dirt Bike appeared first on STOLEN 911.
      View the full article
  • Similar Tagged Content

    • By Mark Walters
      Hi guys.  First post, hope you can help.  As above 1991 Honda fourtrax.  Starting, running fine until a few weeks ago. Used primarily to put my ski boat in the garage (put 2" ball on front).  Any way, had just backed boat into garage, turned off to crank trailer wheel down, when I went to restart got nothing.  
      No neutral light, no headlights, no reverse light, would not turn over when start button pushed.  It would crank and run when I jumped the contacts on the start relay.  While running the neutral light will come on, although it is dim and flickers.  Reverse light on when running and in reverse.
      What I have done to this point:
      1.  Used jumper cable to ground battery (-) terminal to engine block thinking ground wire from battery to engine may be bad.  No neutral light, no start.
      2. Applied 12 volts to start relay.  Got a loud click like it was making contact.  I didn't have the battery/starter cables connected to the relay, but I am assuming it would have cranked at that time.  
      3. Disconnected neutral switch wire.  Grounded neutral switch wire with jumper wire. No neutral light, no electric start. 
      At this point I am thinking ignition switch vs broken wire in the harness going to the neutral switch (due to dimness and flickering when running).
      Any and all suggestions to help track down this issue are appreciated.
      Thanks
       
    • By Connor Tuftin
      I have a 1988 300 Honda FourTrax, All wheel drive.
      My brother and I were fixing up this quad. We put a brand new battery and fuses in and it was running fine until we put the quad into reverse. As soon as it was put into reverse all of the electrical cut out and power wasn't making it to the head unit anymore and both of the brand new fuses popped. We figured there might have been a short from the starter or solenoids, but they are all working properly. At this point we don't know where to start looking for where the short could be. I'm just wondering if anybody has had the same issue or knows of similar issues that could cause these electrical shorts?
    • By Steven Workman
      So I have a Honda Fourtrax 300 year 1988. The ignition doesn’t start it with no sound. The headlights won’t turn on. It has a brand new charged battery, fuses are good, oil is good, gas is good, reverse is rusted, it shifts good, won’t jumpstart but when you try it will turn over, it will start if you jump the solenoid give it gas and spray starter fluid on the breather but it won’t stay on long but will stay on for the little time it does by itself. I don’t know what’s wrong and I need help!
    • By Arnold Schimberg
      Hi Guys
      I have 88 4trax FW , it has a booster circuit
      In the cdi control fed from a leg in the alternator. 
      MY Honda service manual says you will get no spark without this circuit on this model. 
      Can someone explain a little about this please ?    Thanks
    • By Dhenness
      Can someone tell me if the wheel cylinders  for the 1986 Honda Fourtrax TRX200 match other years and models?  I can't find a 1986 wheel cylinder rebuild kit on the internet.  I see a TRX250 and wondered if it was a match.  Which models use the same caliper?
  • Recently Browsing   0 members

    No registered users viewing this page.


×
×
  • Create New...