Quantcast
Jump to content

  • Do you own an ATV? Join our Forum!

    As a member, you can post in our forums, upload your photos and videos, use and contribute to our downloads, create your own member page, add your ATV events, and even start your own ATV club to host your own club forum and gallery.  Registration is fast and you can even login with social network accounts to sync your profiles and content.

wjh1599

2005 Suzuki 500 Vinson - Shifting Problem

Recommended Posts

I recently acquired this quad . Runs great but it will not shift into park. Don't want to tear into the rear differential without a general idea of what to look for. Are there any suggestions?

Share this post


Link to post
Share on other sites


i believe the vinsons had transmission problems from the start. someone correct me if i'm wrong, but, from what i have been reading, suzuki offered a shift kit for troubled machines. some machines were hard to shift (non-automatics) and other problems included being stuck in a gear. it was an expensive job to do, so i think if it was me, i would be somewhat ok without it going into park and count my blessings that every other gear is working fine. i know it's best if the bike works properly, but the fix was about 1500 - 2000 bucks. is yours an automatic or toe shift ?

ck1999_400ex might be a good guy to get ahold of here if no one else jumps in and gives a heads up.

Share this post


Link to post
Share on other sites

Id start by looking at the linkages first, and just adjust the main rod one way or the anther. Take a note of where the rod is to begin with so you can adjust it back if you get no resalt

Share this post


Link to post
Share on other sites


Thanks riders. The rod seems to be fine. Theres a plug on the top of the differential at the shifter and if I loosrn the plug or even remove it it will move or even shift into park. Thats ss far ad I have gone with it. Its got the foot shift. At that cost I can live with it. The quad was given to me by a real close friend who new someone who stopped riding a few years ago. The quade sat for three years.

Share this post


Link to post
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.


  • Similar Tagged Content

    • By Alois Specht
      Hi there , have a KAZUMA 500 JAGUAR the rear diff is permanently locked , how can I get it out of lock just about tried everything I think, ?? .  Thank you your help is appreciated.
       
    • By mrfartsalot
      i have a 2001 suzuki quadmaster 500 4x4 that the primary cvt clutch is rusted on any ideas on how to get it off i want to try to reuse it if possible.
    • By Paul Maple
      I have a 1999 Sportsman  500, it was running fine, than started to lose power in the winter, I adjusted the idle screw and away I went, than a few weeks ago it died, I have found that i am flooding the engine, compression was at 70PSI and due to the compression release mech. i assume i am good as it compared to the same PSI on a 2000 sportsman 500 i have. i cannot start the atv unless i go full throttle and it starts an runs for about 30 sec than dies, again it is flooded. i ordered a new carb off ebay as i could get one for around $40. put that in same issue, i have checked the timing, (good), valves out of adjustment i adjusted to .006 still same issue, i have found the exhaust lobe and rocker arm to have some wear, i have ordered new ones, but am looking for any other input in this area as well. would the exhaust cam and rocker arm cause the engine to flood? i have used a bore scope and the piston liner has good cross hatching still? any input would be great.
    • By colin james
      View File 1996-2000 Polaris Sportsman 335/500 Service Manual
      This is the factory service manual for the polaris sportsman 335 & 500.
      You can download the section you need  or download all of the chapters for the complete manual 
      Submitter colin james Submitted 10/19/2018 Category Polaris ATV  
    • By colin james
      This is the factory service manual for the polaris sportsman 335 & 500.
      You can download the section you need  or download all of the chapters for the complete manual 
  • Similar Topics

    • By Abbeypalm
      While cruising, my 2011 750 king quad suddenly shut down. As it happened, red lights on the display flashed. Any ideas? My head lights suddenly stopped working about a week ago, if that helps. I have no power at all. Thanks 
    • By Brennon Heflin
      So I bought a 2000 quad runner 250. I'm having some issues an wondering what it could be I replaced the pet cock valve an the fuel filter an pump inside tank I also put a voltage regulator on it. The problem I'm having is that when u give it half or more throttle it bogs down an loses power what could it be the bike is almost like new an cant figure it out any help would be great
    • By Susan Makowski-DeGraw
      My quad runs,  it starts up runs for about 10 minutes and then it dies if you let it sit for 10 minutes it’ll start back up ride for another 10 minutes and then die again, trying to figure out why it keeps stalling
       
       
    • By smitht18
      Looking for the rectifier.  Most bikes have near magneto.  It appears the KQ has it in front.
      Can someone tell me exactly where it is? 
      Bike not charging and magneto checks out ok
    • By Hunter19
      How are you doing guys I just joined I have a 1998 Suzuki King quad I’m having problems with high RPMs the ATV idols perfectly but soon as a throttle up it doesn’t stall but it just bogs down it has no power any suggestions thanks
  • Recently Browsing   0 members

    No registered users viewing this page.


×
×
  • Create New...