Quantcast
Jump to content

  • Join Today, It's Simple and FREE!

    As a member, you can post in our forums, upload your photos and videos, use and contribute to our downloads, create your own member page, add your ATV events, and even start your own ATV club to host your own club forum and gallery.  Registration is fast and you can even login with social network accounts to sync your profiles and content.

copedaddy

Sportsman 90 bogging down

Recommended Posts

Have a 2000 Sportsman 90 I picked up for my youngest son. It had been sitting and would not start, so I pulled and cleaned the carb, cleaned the tank, put fresh gas in it and it fired right up. It seems to run out good, but after riding it for a few minutes when you de-cellerate it bogs down and will slowly stall out or drop down to a low idle.

I can fire it back up and it will pick up ok, but every few minutes it seems to want to bog down and throttle response is non-existant. Fuel and plug are fresh.

It does seem to be pretty smoky with the auto oil injection. Could to much oil cause this type of behavior ? Anything else to check?

Thanks

Share this post


Link to post
Share on other sites


Check your gas tank vent, might be plugged. Does it suck in air when you loosen the gas tank cap after it stalls out? Just a thought.

Share this post


Link to post
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now

  • Similar Forum Topics

    • By Christian Brindle
      I have a 2000 Polaris Sportsman 500. A year or so ago we got it running after replacing the kill switch. It ran great but after some use for a couple months it got a flat tire and for some reason we just forgot about it and it sat for some time. Before it sat i replaced the gas cap, fuel filter, fuel pump, petcock, battery, starter relay, oil and oil filter. I recently went to start it and it started so quickly and without choke or throttle but the ATV wouldn't move till about 1/4 throttle and it wasn't really a smooth ride until 1/2 throttle. it also would bog out randomly after you came to a stop and sounded like it was getting too much fuel. I cleaned the carb and adjusted the air/fuel screw to 1 3/4 turns out.  I also messed with the idle and the throttle cable adjuster up on the handlebars. It's safe to say it now runs worse than when i started working on it 2 days ago. It takes more effort to get started and bogs out idling after about 30 seconds. I tried adjusting the idle but every time i do it'll get to a sweet spot but after driving it down the driveway and back the idle will go up and down to the point where i can't put it in gear because the gears will grind. Any thoughts or ideas would be greatly appreciated. Thanks
    • By 4tracker
      I'll keep looking/asking until I find someone that's in same boat, or atv as I'm in lol Well maybe not the exact same atv, any atv would be ok lol
      Riding skills from slow poke to flat WOT is fine with me, as long as were out there in Gods country!! Get in touch before the season starts to get acquainted before hand! Thanks, Steve


    • By joninak
      Well, it overheated then started blowing white smoke!!
      I have it torn down & the cylinder appears to be warped. Going to have the head checked out next but in the meanwhile... Does anyone have the torque sequence/specs for the head bolts??
      TIA
       
       
    • By JacobSlabach
      Got a 04 Sportsman 500 that wasnt running- owner said it needed a stater and a new battery.  It ran rough (been sitting out in the weather for a while).  A friend and I started by adding a new battery and it would start barely with the choke and his hand over the air-filter.  I decided to install the new battery in the holder on the side.  we had it on the rack because the old on was still in the bike.  I tried to be nifty by turning the battery to put the terminals in an easier spot to get to, but forgot to reverse the cables too.  In a sentence, I reversed the positive and negative on the battery like a dummy.  When we discovered my mistake and corrected it, we turned on the bike, but the display did not light up and the key did not turn on the starter.  jumping the solenoid worked the starter, so we thought the solenoid just burned up when I reversed the pos and neg...  new solenoid and no difference.  what have I burned up?  Also, the shifter does not seem to do anything in the trans.  it slides back and forth like its stripped in the trans.  any help would be appreciated!!
      I think the biggest issue right now is the electrical.
    • By joninak
      I'm working on a 2018 Sportsman 570 and found in the service manual that there are two different torque methods for the head bolts depending on whether the bolts are silver or black. Well, silver bolts came out of my engine and I'm going to be replacing them with new bolts, however the parts fiche doesn't specify bolt color or that there is even an option!?! 
      Has anyone on here been through this before and can offer insight??
       
      TIA
       
  • Similar Tagged Content

    • By BionicRival
      I have a 1997 Polaris Sportsman 500 4x4 that recently started bogging. Was riding down a road and all of a sudden started bogging. I tore the carburetor off, cleaned the jets , checked if there was spark. I'm pretty much out of ideas. After cleaning the carburetor, put it back on an now it wont start. Any ideas?
    • By ut1w7b
      I have a 94 sportsman 400. It sat for several years before i got it. I have cleaned the carb it will start and run for about 5 min then it will flood. I have torn it down and cant see anything wrong. has anyone else ran into this problem any hel would be great.
    • By buzzar56
      I am looking for a free repair manual for a 2003 Polaris sportsman 500 ho atv. all the posts on here lead me noplace
      thanks fred.
    • By bodatiouskid
      Have a 2002 Polaris Sportsman 700 that only has 34mi. on a carb & ring job.
      Cut the gas off today to drain carb.Now engine will not idle.If I open throttle will run,but let off & will cut off.Can screw idle in with no change.
      What happened? Why did this happen when fuel ran out?
      Please help me,my ATV is a daily driver.
      Please help!!
    • By warkcol
      I am having an issue where it sounds like the gears are slipping if I hit the throttle really hard and also after letting off when the engine brake is applied. Also, the drive train that goes to the front also rides again the gear shift box. I will attach pictures and a video here shortly.
      Thanks in advance!
      [ame]
      [/ame]https://postimg.org/image/cdlu6fza9/
  • Recently Browsing   0 members

    No registered users viewing this page.


×