Join Today, It's Simple and FREE!
As a member, you can post in our forums, upload your photos and videos, use and contribute to our downloads, create your own member page, add your ATV events, and even start your own ATV club to host your own club forum and gallery. Registration is fast and you can even login with social network accounts to sync your profiles and content.
Hi, I'm new to ATV/UTV's and am looking for any advice that would help to repair my 2018 Ranger 500. I got it from an insurance auction and have never owned one before.
It looks like it was sunk deep. Found rocks and sand in the roof, milky oil in the air filter box, water in the fuse box, etc.
So far, I've cleaned the air box out, vacuumed most of the rocks and sand, checked the engine, trans and diff casings for cracks/leaks.
The battery would not charge while connected so I know there is some short somewhere...probably the wet fuse box.
I plan on drying out the fuse box and all connectors with a hairdryer tomorrow, check the fuses, remove/dry out the ECM and disassemble/clean the air intake. Then install the battery and see if i can get it to key on and see what kind of lights I get.
Need to know what to expect with the engine/trans...
It appears that the Service Manual thread at top of forum is dead as all the links no longer work. I'm actually looking for service manual for a 2000 KVF300 Prairie that I just picked up. Does anybody have link to one that they can share, or know where I can find one? Thanks in advance for any help.
Trailer loaded with four wheelers attached to truck in front of our house, . They pulled receiver out spun it around and left.. Came home no trailer or 4 wheelers.
The post 2 ATVs and trailer stolen appeared first on STOLEN 911.
View the full article
By colin james
View File 1996-2000 Polaris Sportsman 335/500 Service Manual
This is the factory service manual for the polaris sportsman 335 & 500.
You can download the section you need or download all of the chapters for the complete manual
Submitter colin james Submitted 10/19/2018 Category Polaris ATV
Similar Tagged Content
Hello, great forum here!
I bought a non running 1998 Big Boss 500 6x6. The previous owners had done quite a bit of work to it. It has a new carburator, fuel pump, starter, adjusted the valves, new mid sprockets and chain. But they said it wouldn't run.
When I got it home I did get it to run, though not very well. It doesn't want to idle and there is a very loud knocking. I didn't run it very long. Hopefully it's just the clutch knocking. It has 4000 miles on the odometer. I popped off the valve cover and the cam looks ok, (it's not flat!) I haven't measured it yet. I still need to check compression.
There's no oil in the gearbox, found a crack in the case behind the output shaft. Looks like a mounting point?
I think I'll try and find a case half. I should probably tear apart the gear box first, it might be in bad shape inside. Who knows how long it was ran without oil. It does shift between all gears.
The rest of it is in fair condition, normal wear and tear for 4000 miles.
Sorry I don't have any pictures of it other than the cracks.
I should probably make sure the motor is good before I put money into the gearbox.
Any tips on things to look for would be appreciated!
By colin james
View File 2000-01 Polaris Sportsman 500 6x6 Service Manual
This is the factory service manual for the 2000-2001 Polaris Sportsman 500 6x6
Download all chapters for the complete manual or just download the section you need.
Submitter colin james Submitted 01/02/2019 Category Polaris ATV
Recently Browsing 0 members
No registered users viewing this page.