Quantcast
Jump to content

Recommended Posts

Posted

I own a 1998 Yamaha Big Bear 350 4x2. It has hydraulic drum front brakes and mechanical single drum brake in rear. When I bought the quad a yr ago the brakes barely worked. I installed rebuild kit for brake master cylinder, replaced wheel cylinders up front, front/rear shoes, and replaced rear brake cable. The front brakes grab sort of ok now, but the rear barely grabs at all. On a side note; If I drive through any trails with muddy water, moisture is getting inside the drums. Worse in the rear drum. These drum brakes have never worked great. They slow me down but don't have enough bite to lock up the wheels. Now I have considered my drums may have worn thin, therefore causing the shoes to not make strong enough contact (???) I'm guessing. The front brakes are spooned out so they fit snug and they work just ok. The rears I have adjusted close to the maximum setting for the actuator arm. I read online about a Yamaha 1998 Big Bear 4x4 owner using a 2004 Big Bear 4x4 front disc brakes on it. He did have to dremel and drill out the lower ball joint to make new knuckles fit since the 04 knuckle has it's ball joint on bottom. It sounded cool and the owner claimed it stopped better. I'm considering a conversion, but it sounds expensive. I hate sinking $400+ worth of disc brake parts into a quad a bought for $500, and I already replaced the existing brake parts I previously listed. I'm just tired of my brakes working poorly and every time I get into some water on the trails the drums look like a septic tank inside the next day. I live in FL and this is the land of the Swamp. There is no avoiding mudholes and water. I would like some brakes that could survive any wet conditions. Any suggestions or helpful advice is appreciated.

Posted

i have a '91 BB with drums on the front and (single) disc on the rear.

WhyTF they engineered it that way is beyond me ???

i have searched online in forums and with conversion manufacturers and have yet to see anything for the BB's. i have seen tons of stuff for honda btw. it seems the only way you can do it is to start swapping out differentials with a later model, to avoid alot of fabrication, but, there would be alot of work going that route too. i have just come to the fact that i'm stuck with drums on a 20+ year old bike and love my grizzly that much more LOL

Posted

LOL! Very True. I came to the same thought after researching the work entailed in converting the old beast. It's a great solid atv and has never left me stranded. Luckily the engine braking on this thing works great so I can usually stop even when the crappy drum brakes are barely working. I just like to use a parking brake when I load my big bear on my flatbed trailer and this rr brake sucks. I'm in the market for a larger newer quad so I think this old machine will remain with it's awful drum brake system.

Thanks for the advice Oxi-Blk.

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Popular Now

  • Similar Forum Topics

    • By hengstserepair
      Howdy ya'll. I am working ona 2000 Yamaha Breeze 125. It was in rought shape when I received it and I am working through issues as they pop up. The quad had been sitting for years. I was able to get her running again, but I need your help with the following issue:
      I don't trust the transmission yet and I don't want to make problems any worse. So, I haven't pushed things hard at all. Low rpms, less than 5mph in reverse.

      Nuetral: Runs as expected
      Reverse: She seems to be driving fine at slow speeds. Going into reverse at idle is fine, coming out of reverse back into neutral won't work (the shifter is just stuck). As soon as I turn off the quad, I am able to shift around without any issue.
      Forward: It slips. It seems to only transfer power to the wheels on a smooth surface and going slightly downhill. When shifting into forward at idle, there is a clacking sounds during the transition. Shifting back to nuetral works just fine.

      Other Notable Symptoms: There was old oil in the vbelt and when I was tuning the carb, it starting blowing out of the CVT cooling vent at the front of the quad. Made quite a mess. There is positive crankcase pressure due to piston blowby, that I have not decided whether or not I am going to fix (customer budget dependant).  Since the oil was old, much darker than the new oil that is in the crankcase, I am thinking it seeped past a bad seal while it was sitting for years. The oil that was in it when I first got it had gas in it.

      Thoughts: I am thinking maybe there is an issue with the clutch. I worry about the old oil intermingling with the dry centrifugal clutch. I was thinking my next step would be to take the cover off of the clutch and inspect it.

      Let me know what you all think. Any advice and ideas is greatly appreciated. This is only the 3rd quad I have worked on and I have a lot to learn.

      Lorne
    • By Rockbottom
      2008 400 big bear was running now will not start
      have power to relay, in neutral, press start have power to starter but nothing happens starter does not turn
      i have good ground at battery to frame and added ground from wire harness to frame beside batter/ frame ground
      blue white wire to cdi has power with key on
      I believe the neutral lock out is working since is was before i shut it down
      if i put  it in gear and hit the start button with key on the relay does not click or send power the starter
      The 3 wires at the relay have power with key on
      What should i test next?
      thanks ahead
    • By Mister907
      Hi guys, I have a 2004 big bear 400. Last winter while plowing the driveway, I heard a loud pop from the left side of the engine. It continued to run as I looked for leaky fluid, but then died shortly after backing it up and won’t start now. The oil light comes on when I try to start it, no noise or anything else. 
      No blown fuses that I can find.
    • By jeffinotown
      Hey guys and gals. I've been working on my friends 2007 big bear IRS. Unfortunately after 3 different people got their hands on it and only made things worse every time.  After months of finding just crazy problems everywhere. I'm finally at the point we're its almost 100% !!! But I'm getting a short somewhere between the 4xW switch I believe. I managed to by searching the internet like a  fiend, got my hands on an official Yamaha wire harness for the year and make. But I don't have the numbered component list and to be honest. After hours of going through and making everything so it's  easy to reference. If anyone has a picture of the referenced components. I would be forever in your debt. I've spent hours marking up the blown up diagram so it will be easy, for any possible future repairs. Please and thank you. Here's a picture of what i have so far.  Unsealed it in plastic so oil and crap won't spill or get smudged. This damn things worth it's weight in gold.              Thanks Jeff                2007 Yamaha big bear 400 IRS.       YFM40FBW
    • By TomJulio
      Looking for two stock front wheels for 92 TRX300 2WD.   I think they are 6 x11" size.     
×
×
  • Create New...