Quantcast
Jump to content


Need help 1991 big bear 350 4x4 with no spark


Recommended Posts

I have a 91 big bear 350 4x4 with no spark what's making me puzzled is my coil is up to spec with ohms my stator and pick up coil is up to spec brand new and ohms reading checks out I got power from CDI coming out and power going in my coil wire from coil to CDI is getting good ohms reading plug is brand new but still not getting spark any suggestions or help would be appreciated I'm getting confused where do I go next please help me thanks 

Link to comment
Share on other sites

  • Admin changed the title to Need help 1991 big bear 350 4x4 with no spark

Even though you have voltage coming to and from the cdi does not conform it’s working.  

Two ways to see if it’s the cdi. 1 is find a used on from another bike same type and swap it and see if that fixed it. 2 is try to dry it out and see if that works.  Most cdi units go bad due to moisture.  Try to put it in the oven for 10 min on 250 deg.  Let it cool down and give it a shot.  If the spark works then obviously a cdi replacement is needed. The heating it up is only a temp fix as it will loose spark again. 

This worked for me but I had to replace the cdi bc it def failed again after a day or two due to moisture re entering the cdi. 

As far as testing the stator and regulator, ignition coil are all within spec with an ohm meter ? 

Link to comment
Share on other sites

The two black wires on the brake lever ? A parking brake that has to be pulled in for the bike to start? I don’t think a bike of that age would have that. But double check. Also the kill switch. Simple test is to look for the two wires that kill the bike. Most are black with a white stripe and all black.  You have to put a continuity tester on the two wires at the switch and see if it rings when you hit the kill switch.  In order to do this properly you have to have the manual to see exactly what wires to test  

Have you tried what i said with the cdi ?

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Forum Topics

    • By Flash_fella
      I had a sudden loss of spark in my 1988 Suzuki LT300E quadrunner and we tried a new plug but still no spark. Then we checked the boot and there was no issues with it. I then took off the coil as I was going to get a resistance reading with a multimeter however I cannot find anywhere what the readings should be. The coil is a Mitsubishi F6T 411. Any help would be appreciated. 
    • By pitts
      Just joined so I can download a manual and In the process of making my 10 posts.
    • By Brantley11
      Hey everybody,
       
      My proficiency is with Hondas and Yamahas make me see RED!
       
      This bike is my brother in law's, it has 1199 miles on it and went from running great to dead with no start. Every once and a while it will start and sputter for 2 seconds. It is extremely sporadic when it fires but never runs for longer than 3 seconds. 
       
      Here is where we sit:
      Brand New Fully Charged battery
      Carb was cleaned with air hose and carb cleaner then into the ultrasonic cleaner with Aircraft aluminum cleaner
      New Shindy Carb kit (made in Japan version)
      Cleaned out petcock and gas tank
      New 93 Non Ethanol Gas
      New Spark Plug
       
      It gets a spark through the spark test light every time
      Bluish white spark
      When holding the spark plug 1/4" - 3/8" away from head it will jump and spark to the head
      Good Compression
       
      Here are the readings:
       
      Pickup Coil 519 Ohms (range 459-561)
      Charging Coil 266 Ohms (range 270-330)
      Lighting Coil 0.700 (range 0.702-0.858)
      Spark plug Cap 10.58 Ohms (10kohms
      Ignition Coil Primary Coil 0.5 ohms (range 0.18-0.28 ohms)
      Ignition Coil Secondary Coil 8.20 kOhms (range 6.32-9.48 kOhms)
       
      Would y'all think stator and pick up coil, rectifier or CDI are the culprit?
       
    • By 86ccord
      Starting this build thread to keep up with everything on my build and hope to motivate someone!
       
      I picked up this 2008 Yamaha Big Bear 250 2 weeks ago. A guy that I hunt with parked it at the hunt club for a year or so before I asked him if he wanted to sell. He said " fill my feeder and throw some batteries in my cameras, and you can have it". Sounds like a deal to me! 
      I have attached some pictures of how it sat under a tarp in the woods and when I got it home and cleaned up a little. 
       
       



    • By newguy024
      Just got into ATV riding just last week, never had much money so i couldnt afford to buy anthing, so now at the age of 34 i just bought a 1987 suzuki quadrunner 300 for 500$ took it out a few times and what a rush of excitement to go through that first mudhole haha!
×
×
  • Create New...